Is It Ok To Mix Diesel And Kerosene?

If you go about on the internet, you can come across a forum question like this:

In most cases, the responses are mixed. ‘Don’t worry, you’ll be OK,’ said half of the people. “Watch out for ________,” the other half will warn.

Regular diesel is referred to as #2 diesel fuel oil, whereas kerosene is referred to as #1 diesel fuel oil. Some people believe it is similar enough to conventional (#2) diesel fuel that they may try to use it interchangeably. What would motivate them to do so, and what problems may they face?

What Makes Kerosene What It Is

The qualities of kerosene determine what happens when it is burned. Because kerosene is a lighter diesel oil than #2, it is referred to as #1 diesel. Because of its smaller weight, it has somewhat less energy – roughly 135,000 BTU per gallon vs. 139,000 BTU for #2.

Aromatic compounds are often concentrated in #2 and heavier diesel fuel oils; kerosene does not have extremely significant levels of them. This is one of the reasons why #2 diesel burns drier and with less lubricity than kerosene.

Drier burn

The most prevalent worry is kerosene’s dry burn, which can harm gasoline pumps. In comparison to #2 diesel, kerosene has extremely little lubricity. When running on kerosene, gasoline pumps without lubricity suffer a lot of wear and may burn out. Additional wearable pieces, such as rings, gaskets, and valves, are mentioned by some. Adding some automatic transmission fluid to the kerosene is a simple cure for this. In this case, 2-cycle oil can also be used.

Hotter burn?

Some will argue that kerosene burns hotter than #2 diesel, resulting in worries about rings being burned out. Others argue that because kerosene has a lower energy value, it will not burn at a higher temperature.

The fact that kerosene has less total energy than #2 is undeniable. However, having less total energy simply means that a gallon of kerosene produces less total heat than a gallon of standard on-road diesel.

Kerosene has a lower viscosity than gasoline, which allows it to burn at a higher temperature in an engine.

Cutting Diesel with Kerosene

Kerosene can be combined with diesel fuel for a few advantages. Kerosene is particularly beneficial in the winter for modifying the cold weather handling temperatures of diesel fuel. The rule of thumb is that adding ten percent kerosene to a diesel fuel blend lowers the cold filter plugging point by five degrees. It may be more cost effective to use kerosene as a mixer than than a cold flow polymer in extremely cold climates.

To reduce emissions, kerosene and #2 are mixed together. According to the theory, kerosene “burns cleaner” than #2, resulting in lesser pollutants.

Can you mix diesel with kerosene?

It is dependent on the engine you have. Kerosene burns cleanly in most diesel engines and does not affect them. In reality, kerosene is an acceptable fuel in many contemporary diesel engines. Kerosene is produced through a distillation process, making it a pure fuel. This signifies it doesn’t contain any additives like diesel. As a result, kerosene burns cooler than diesel and lacks the lubricating additives found in diesel. This means that if you use kerosene in your diesel engine, it will place a strain on your injector pump unless you use the proper lubrication. Add a quart of Marvel Mystery Oil to every twenty gallons of kerosene in your tank to achieve this. Kerosene should not be used in a diesel engine unless it is listed as an acceptable fuel in the owner’s manual or you have confirmed with the manufacturer.

Is it OK to mix diesel with heating oil?

Yes, yes, yes, yes, yes, yes, yes, yes, yes, yes, yes, yes, yes, yes Diesel is near enough to home heating oil to be used as a replacement, and it burns safely. In fact, our experts advises keeping a moderate amount of diesel on hand in case of an emergency, as you never know what can happen, such as terrible weather or an unforeseen supply shortfall.

However, keep in mind that if you decide to keep diesel at home, it must be stored in the proper container (yellow denotes diesel, red denotes motor gasoline, and blue denotes kerosene, just so you know!). You should never keep diesel fuel for more than six months at a time since the quality diminishes and it becomes dangerous. Even if you use fuel additives to extend the life of the fuel, storing it for a year is the maximum amount of time that is prudent.

However, this should only be a short-term remedy! While diesel is totally safe and functional as a temporary heating oil substitute, it isn’t meant to be stored in your tank for long periods of time. Diesel fuel is an excellent alternative in a pinch, but it is ineffective and not recommended for long-term heating.

Can you mix diesel and kerosene for a heater?

Before using diesel in a kerosene heater, there is no need to add anything to it. However, many people claim that using chemicals improves their performance.

  • Isopropyl alcohol: For each 5 gallon can of diesel, add 40ml (a little more than 1/8 cup) of 91 percent isopropyl alcohol. I’ve also seen far greater alcohol-to-diesel ratios advocated, such as 80ml per gallon.
  • Kerosene: Kerosene and diesel can be mixed in any ratio and burned in your heater. The most common recommendation is to use a 1:4 ratio (1 part kerosene to 4 parts diesel).

Keep in mind that you should always have a backup plan in case of an emergency. Other emergency home heating methods can be found here.

Do you have a kerosene heater that runs on diesel? What advice do you have to offer? Please share your thoughts in the comments box below.

How much kerosene do you add to diesel?

To improve winter fuel operation, kerosene is combined with diesel fuel. Depending on the severity of the cold weather, kerosene blended diesel fuel is mixed in ratios ranging from 80 parts diesel to 20 parts kerosene to a maximum of 50 parts to 50 parts combination. While kerosene has a similar igniting quality to #2 diesel fuel, it is too thin to be used as a standalone engine fuel and lacks the lubricating properties of heavier #2 diesel. The vehicle owner or operator can combine kerosene with diesel fuel.

Can I use fuel oil in a kerosene heater?

This is strictly for educational purposes; heating oil or any other sort of oil should not be used in a kerosene heater.

Kerosene is a light grade of diesel oil, sometimes known as No. 1 in the industry. Heating oil, often known as No. 2, is thicker and less flammable than kerosene. Heating oil will smoke and generate foul smells when used in a kerosene heater. It will also leave unburned deposits on the wick and burning mechanism, necessitating more frequent cleaning and maintenance. While heating oil may work in a kerosene heater, it does not appear to be worth the effort.

What is green diesel?

On-road diesel is either clear or somewhat green in appearance. When diesel fuel is freshly dispensed into a bottle to observe its color, refineries add a green dye, which is visible. This dye fades to yellow or darker colors as the fuel ages. Checking the fuel for a “bright” appearance, with the faint green dye being a giveaway that the diesel is new and in good condition, is part of a visual inspection to assess diesel fuel quality.

What is dyed diesel?

Diesel contains dye in almost all of it. When we talk about dyed diesel, we usually mean a red dye applied to off-road diesel. Off-road diesel is typically used for heating oil, construction fueling, agricultural use, and other off-road equipment not needed to pay fuel taxes on the highway system.

What is farm diesel?

Off-road diesel, often known as farm diesel or diesel for agricultural purposes, is diesel that is not subject to on-road fuel taxes. Diesel fuel used for agricultural purposes is tax-free. Taxes can be avoided if diesel is burned on a farm and can be tracked. In Oregon, farms are able to obtain clear diesel without paying any road fees. It is frequently coloured red to indicate that it is tax-free. Some farms may track their use of clear diesel so they can submit for Federal road taxes for off-road usage in Oregon, where P.U.C. for trucks over 26,000 GVW pay a weight mile tax instead of a per gallon state road tax.

What color is dyed diesel?

Every gallon of fuel sold in the United States contains some color. Diesel for on-road use usually has a slight green hue. This is a dye that is mixed into the fuel by either the refiner or the terminal supplier. Off-road diesels are coloured red to indicate that the fuel is tax-free and intended only for off-road use.

Why is diesel dyed?

Diesel is coloured to indicate whether or not it has paid road tax. In the United States, on-road diesel usually has a faint green hue. Off-road diesel is dyed red to indicate that it has not paid the required road taxes in all states and by the federal government.

What is off-road diesel?

Off-road diesel is diesel fuel that has been dyed red to indicate that it is tax-free and only available for off-road fuel uses such as construction fueling, equipment that is never used on a public road, agricultural use, heating oil, boiler fuel, and other non-taxed diesel fuel uses as defined by state and federal fuel tax laws. Some off-road users in Oregon can use the Oregon state tax exemption to buy on-road fuel if they have the correct papers.

Is dyed or off-road diesel flammable?

The National Fire Code classifies off-road diesel as a Class II combustible liquid. A flammable fuel has a flash point below 100 degrees Fahrenheit. The flash point of diesel ranges between 126 and 205 degrees Fahrenheit (typically assumed to be about 160 degrees F). As a result, it’s classified as a Class II combustible.

Is off-road diesel or dyed diesel high sulfur diesel?

Dyed diesel (also known as off-road diesel) contains a lot of sulfur. Diesel fuel having a sulfur level of more than 500 parts per million is known as high sulfur diesel.

Is off-road diesel or dyed diesel ultra-low sulfur diesel?

Off-road and colored diesel fuels may have ultra-low sulfur, however this is not always the case. In the United States, there has been a persistent campaign to reduce sulfur in all fuels, led by EPA regulation. Off-road construction and agricultural equipment have been required by EPA rules in recent years to have an emissions system that allows ultra-low sulfur to function without serious difficulties. As a result, today’s off-road diesel is ultra-low sulfur. If you have a tank with old dyed red diesel fuel in it, you can infer it has a sulfur concentration that is higher than ultra-low.

What is dyed ULSD fuel?

Dyed ULSD fuel is ultra-low sulfur diesel that has been dyed red to indicate that it is only intended for off-road or untaxed use. Heating oil, construction fuel, agricultural fuel, generator fuel, and other off-road uses are common uses for this type of fuel. The abbreviation “ULSD” stands for ultra-low sulfur diesel.

Is dyed diesel #1 or # 2 diesel?

Diesel that has been dyed can be either #1 or #2 diesel. Both fuels must include a red dye to prove that they are untaxed and cannot be utilized as on-road fuels.

Why does the government require diesel be dyed red?

“For two reasons, the federal government demands dyeing of untaxed diesel fuel and kerosene. To aid in the reduction of tax fraud by recognizing fuel that hasn’t paid excise taxes and to aid in the reduction of air pollution by identifying fuel that isn’t acceptable for use in highway vehicles.”

Is dyed diesel and off-road diesel kerosene?

Kerosene (which crosses as #1 diesel fuel) can be found in dyed diesel and off-road diesel, but it is not always the case. Do not mistake a dyed fuel for kerosene, which is a more uncommon fuel. Kerosene differs from #1 diesel in one way: it has been proven that it may be absorbed and taken up by a wick. All kerosene is classified as #1 diesel. Kerosene isn’t found in all #1 diesel fuels. Diesels that have been colored and off-road fuels are in the same boat. All coloured kerosene and off-road diesel are dyed. Kerosene isn’t the only coloured fuel.

Is dyed diesel and off-road diesel stove oil?

Stove oil is coloured diesel and off-road diesel. Similar to diesel, it’s usually a #1 or #2 stove oil. Stove oils, as opposed to diesel, had a slightly distinct set of specification problems in the past, which is why they were named “stove oils.” It was less precise when petroleum refineries distilled crude oils to make diesel range fuels than it is now with hydrocracking technology. The number of distillate range fuel requirements is significantly more concentrated today, thanks to both oil refinery technologies and EPA emission standards, in order to assure compliance with EPA and state rules. If your heating appliance requires stove oil, it will most likely require #1 stove oil or #1 kerosene. This product is supposed to produce less soot, making it better suited for use in a pot stove. Monitor and Toyostove thermostatically controlled direct vent heaters are the most current stove oil appliances in the United States.

Is off-road diesel bad for my truck?

It depends on the year of your truck, and we’re assuming you’re talking about red diesel fuel. To begin, it is illegal to use dyed diesel, off-road diesel, or heating oil in an on-road vehicle. If you are found in Oregon, you might face a punishment of up to $10,000, and the state is very aggressive in pursuing tax evasion. Beyond the usage of off-road fuel, which is legal. On the west coast, coloured diesel is often ultra low sulfur fuel. This means that if it’s burned in your engine, it won’t cause any problems. It may be high sulfur or low sulfur fuel, depending on the age of the colored fuel or whether it is genuinely a heating oil. If you use that fuel in a post-2007 engine with a particle trap, you’ll have major maintenance problems.

Is dyed diesel or off-road diesel heating oil?

Yes, colored diesel and off-road fuel can be used to heat your home. These days, most dyed diesel and off-road diesel is ultra-low sulfur diesel. According to the EPA and most state rules, heating oil can have a low or high sulfur concentration. So, while heating oil cannot always be colored diesel (when used for off-road machinery or agricultural purposes), dyed/off-road diesel can always be used for heating oil and meet the requirements of heating oil furnaces.

Does off-road diesel freeze?

At low temperatures, off-road diesel gels. Wax crystals form and fall out of the diesel at lower temperatures, clogging filters and gelling the fuel. Water and naturally held-in diesel will also ice up, clogging filters. Diesel gelling is the term for this phenomena.

Does off-road diesel gel in cold weather?

If it gets cold enough, all diesel fuels will gel. Wax crystals and ice accumulating in your fuel will clog filters and cause your equipment to shut down. As a rule of thumb, if you don’t treat your diesel fuel, it should work OK above 20 degrees F. If the temperature drops below 20 degrees Fahrenheit, make sure your vendor treats the fuel for winter use so it can operate at -20 degrees Fahrenheit. If you’re going to be operating in temps below that, check with your vendor to see if they’ve tested the fuel to work in temperatures below -20 degrees F.

Does off-road diesel go bad?

Off-road and dyed diesel might deteriorate with time. All ASTM-compliant diesel fuels should be safe to store for up to a year without extra treatment or testing. If you’re storing diesel for a long time, it’s a good idea to treat it with a biocide and an oxidative stabilizer to guarantee that it stays within specifications and that nothing grows in your fuel tank. Water and dirt entering the fuel through a tank vent is the worst opponent of long-term diesel storage. A tank will breathe when the temperature changes, bringing in air and moisture from the outside. Keeping your gasoline within specification means making sure there’s no water in the tank and that no outside impurities can get in.

How long can I store off-road or dyed diesel in a fuel tank?

Diesel fuel has a one-year shelf life if left untreated. You can anticipate diesel to last two to three years if it is treated with a biocide to prevent biological development in the tank. When diesel is sampled after two to three years, it loses its brightness and begins to exhibit signs of age. After three years, you’ll want to sample and test the fuel to make sure it’s up to code and safe to use.

What is the difference between off-road diesel and on-road diesel?

The significant difference between the two fuels is the amount of gasoline taxes levied. To indicate that it is both ultra-low sulfur diesel and that the on-road fuel taxes associated with using it to power a highway vehicle have been paid, all on-road diesel is transparent or greenish in color. Fuel that has been dyed has not been taxed and cannot be used to power a vehicle on a public road.

Do you pay sales tax on dyed diesel or off-road diesel in Washington state?

Yes. The sales tax is assessed if you consume colored diesel and do not pay the on-road fuel taxes in Washington state. The sales tax is not paid if you use clear fuel with road taxes connected to it. The Washington Department of Revenue has more information about Washington gasoline taxes.

What are the taxes on dyed diesel or off-road diesel in Oregon state?

Your gasoline distributor pays a modest tax (less than $.01) on the fuel they purchase at the wholesale terminal. The US EPA Superfund cleanup and the “LUST” (Leaking Underground Storage Tank Cleanup Fund) are two of the taxes. Aside from that, there are no taxes on off-road diesel fuel in Oregon (federal, state, or local municipality).

Is there a way to buy clear diesel without a road tax on it?

In Oregon, you can purchase clear fuel that is exempt from state road charges. The following are the requirements for using clear diesel in Oregon without paying state taxes:

  • cars with a legal Oregon “E” plate and registered to a US government agency, an Oregon state agency, or an Oregon county or city
  • Vehicles or farm tractors/equipment that are only used on the roadway inadvertently, as specified in ORS 319.520
  • Unlicensed vehicles or equipment that are utilized exclusively on privately owned property

What happens if I use dyed diesel in an on-road vehicle?

If you are caught in Oregon, you might be fined $10,000 each day. We’ve seen fuel tax evaders nabbed before, so be advised that Oregon is looking for any amount of dye in an on-road vehicle’s saddle tank. You will have maintenance concerns with your vehicle’s emission system if you use low sulfur or high sulfur fuel and your vehicle has a particulate trap.

Can you use dyed diesel in a diesel pickup truck?

Only if the pickup is solely for off-roading. If you plan to utilize that truck on a public road (even to cross a street) and colored fuel is discovered in it, state regulators can (and do) levy fines of up to $10,000 per occurrence. You can use off-road diesel as the vehicle’s fuel if you have a closed facility or a large farm and are not registering the vehicle for on-road use (thus the pickup must not leave the site). Any regulator observing dyed fuel in your vehicle will assume it’s an on-road pickup if you have license plates and it’s approved for on-road use.

How does the government test if someone used dyed diesel?

Typically, regulators may take a sample from the tank or spin the gasoline filter to look for obvious dyed fuel when checking for illegal usage of dyed fuel. If the fuel is clear (or even slightly pink) and they suspect dyed fuel was used in the car, they can use a special black light to show that dyed fuel was in touch with the vehicle. They’ll beam the light on the gasoline filter, the fuel tanks, and other portions of the engine compartment that may have come into contact with the fuel. They will cite the vehicle operator if they detect even a minor trace of the red-dye used in off-road fuel in specific regions. On the internet, there are kits for filtering dye out of gasoline to eliminate the color. Those kits won’t be able to remove enough dye to keep these lights from detecting it.

Why is off road diesel illegal for pick up trucks to use?

Off-road diesel is painted red to indicate that on-road fuel taxes have not been paid or that the fuel is tax-free. Fuel taxes for on-road fuel usage are levied by the federal government and state governments to help pay for the roads we all use. Fuel taxes are deductible if you use diesel for non-road equipment, machinery, or heating/boiler uses, and the fuel is coloured to make its tax-free status obvious. In a roadside or site level inspection, regulators can also shine a black light on certain parts of a vehicle’s system to see if colored gasoline is being used illegally.

What is the difference between dyed diesel and heating oil?

What’s going on in the Pacific Northwest right now? Typically, nothing. Diesel-colored heating oil is used. To reduce the overall cost of the fuel, most petroleum distributors sell the mainstream colored diesel grade for use as heating oil. Heating oil and dyed diesel have varied ASTM requirements depending on where you acquire it. Because furnaces and boilers can manage dirtier, lower-quality fuels than off-road equipment with a particle trap, heating oil specifications have larger tolerances than diesel criteria. Although heating oil is always a diesel fuel, dyed diesel for off-road machinery may have a distinct specification. In Oregon, for example, any dyed diesel fuel used in off-road equipment must include at least 5% biodiesel or renewable diesel. Heating oil and boilers are excluded from the biofuel mandate. Heating oil, on the other hand, can be free of biodiesel, while off-road diesel for machinery cannot.

Can refrigerated trailers or “reefers” use dyed diesel even if they are attached to a truck moving it on the highway?

Refrigerated trailers are, in fact, off-road vehicles. Because its engine is not pushing something along the road, the diesel-fueled refrigeration trailer is considered off-road equipment. Any ultra-low sulfur diesel fuel can be used in these trailers (dyed or clear). If you use on-road clear fuel in a refrigerated trailer and keep track and verification of the on-road fuel used in the off-road piece of equipment, you can get your fuel taxes returned. However, proof is required, so speak with your CPA or accountant.

Can I use kerosene in oil furnace?

After distillation, heating oil and kerosene go through a similar refinement process, but kerosene is refined further, giving it somewhat different qualities than heating oil. Many household and commercial oil furnaces can burn kerosene as well as heating oil.

What burns longer kerosene or diesel?

Because kerosene has a lower viscosity than diesel, it burns hotter. This can assist heat the house, but it can also cause issues if the heater isn’t designed to manage heat that’s hotter than regular heating oil heat. The heat from a kerosene heater may readily heat a standard home in a warm environment if your furnace is suitable for kerosene, according to “The Decatur Daily News.” When diesel is unavailable, kerosene heating oil K-1 is typically utilized; nevertheless, it is more expensive than its diesel cousin. Installing a fuel oil heater also makes it comparable to standard No. 1 heating oil, which is useful if you choose to swap oils later.